276°
Posted 20 hours ago

Yuasa YBX3642-110 12V 110Ah 925A Super Heavy Duty SMF Commercial Vehicle Battery

£9.9£99Clearance
ZTS2023's avatar
Shared by
ZTS2023
Joined in 2023
82
63

About this deal

B. Stop charging when the battery is gassing freely and the battery-voltage shows no increase over a period of at least 2 hours. Yuasa has designed the batteries for the Cargo SHD range with more emphasis on cycling durability than starting power, so the plates used have higher paste densities. To recover the consequential loss in starting performance, more active material has been added to maintain a similar level of performance as the standard Cargo range. Cargo SHD batteries are maintenance possible not impossible, the batteries are designed to be topped up if water loss has occurred. Excess water loss can be caused by many things, amongst the most common are a charging system fault, prolonged operation in hot climates and excessive off vehicle charging.

YBX7000 EFB are the premium choice for high power demands, end of chassis location and are also suitable for vehicles with Start Stop. Built with EFB technology, they feature an electrolyte mixing device to extend battery life and are ideal for frequent overnight stays where hotel loads are applied. Batteries in the range are sealed maintenance free (SMF) with a sealed lid, have XVR and offer an M1 micro-cycle endurance rating. Based on the battery manufacturers market leading YBX automotive ranges, Yuasas new Super Heavy Duty range replaces Yuasas Cargo ranges. It features three levels of conventional flooded types, plus Enhanced Flooded Battery (EFB) options. The majority of commercial chargers, particularly home-chargers, are of this type, and allow neither the voltage nor the current to be preset. Use the same procedure as for Constant Potential Chargers in the paragraph above. Boost Chargers

Returning items to a branch

It is good practice to wait for about 20 minutes for the gases to clear before removing the leads from the battery as some chargers remain ‘live’ and can cause a spark. YBX3000 types are the ideal choice for vehicles with standard power demands and occasional overnight stops. These SMF types have an E2 endurance rating. They also have a superior vibration resistance rating of V3 with DIN types being V4 and suitable for end of chassis location. B. These chargers should be able to charge over discharged (below 11.00V) batteries. Note that some have a special setting for all-calcium batteries. Constant Current Chargers Batteries in the YBX7000 EFB and YBX5000 ranges feature Yuasas XVR Extreme Vibration Resistance. This means that they have a vibration resistance of over eight times V4. V4 is the highest level rating that European standard EN50342 requires. Batteries in these ranges, plus all YBX3000 DIN types, are suitable for rear chassis location fitting. These maintain a fixed, constant, pre-set voltage throughout the charging period. The current cannot be set and will fall as the battery state-of-charge increases.

All batteries once filled with electrolyte become active, and will slowly self-discharge. The higher the temperature that they are stored at, the higher this self discharge rate will be.Yuasas commercial vehicle batteries are already trusted by leading commercial vehicle manufacturers who demand the best and fit GS Yuasa batteries as standard. The new YBX Super Heavy Duty range has been developed to meet the increasing specifications of these top vehicle brands. There are many types of charger available; their working principles and the procedure for using these is given below. Smart Chargers B. Never boost-charge any battery that is below 11.00 Volts as it will be too sulphated to accept a charge; scrap the battery or charge normally. E. If you are charging a battery below 11.00V (over discharged) that has been in service, a specialised charger capable of providing a very high charging voltage may be necessary, and the recommended current may not be obtainable at first. In this case, monitor the current and adjust as necessary during the charge. If a battery has become over discharged, it will have lost both life and performance because of irreversible sulphation. Charging may reduce further its potential life. Constant Potential Chargers

The Yuasa Cargo SHD batteries will cope with the most demanding commercial applications such as vehicles with tail lifts, agricultural vehicles, passenger service vehicles and where vehicles have sleeper cabs fitted with numerous electrical devices. Note. Many customers severely underestimate the amount of time necessary to charge a flat battery. This results in customers returning batteries saying that they have charged the battery but that it is still not holding charge. D. Charge the battery for the number of hours shown in the table below depending on the open-circuit voltage.

Battery Finder

C. Note. The majority of constant potential chargers are incapable of charging a severely over discharged (below 11.00V) battery in a realistic period of time. A minimum of 24 hours is normal. It might be impossible to charge an over discharged battery. Modified Constant Potential Chargers GS Yuasa Battery Europe Ltd have launched their all new Yuasa YBX Super Heavy Duty battery range for commercial vehicles. The four-tiered range is available now and provides one of the most comprehensive and highest specification offers on the market.

Asda Great Deal

Free UK shipping. 15 day free returns.
Community Updates
*So you can easily identify outgoing links on our site, we've marked them with an "*" symbol. Links on our site are monetised, but this never affects which deals get posted. Find more info in our FAQs and About Us page.
New Comment